C270   C 0 M M I S S I 0 N I N G   C H E C K   L I S T - Continued

5. ___ Check for leaks at sink drain fittings, sink drains OK.

6. ___ Put water in ice box and check for proper drainage.

7. ___ Check bilge pump operation, handle present.

8. ___ Check head by flushing and pumping.

9. ___ Check shower sump drain line

10. ___ Check holding, tank, pump vent and fitting.

11. ___ Check head and pump handle for leaks.

12. ___ Main hatch no leaks, slides freely, hatch boards fit OK.'

13. ___ Cabin windows hose tested for leaks.

14. ___ Anchor locker drains OK, no leaks

15. ___ Stove operates OK: Check tank, fuel line, burner and oven.

2.3 RIGGING AND HARDWARE:

1. ___ Mast stepped.

2. ___ Pin, tape and tune standing rigging.

3. ___ Backstay adjuster, whisker pole, spinnaker gear, boom vang, OK.

4. ___ Blocks, cars, cleats rigged OK.

5. ___ Test all winches, winch handles present.

2.4 ENGINE:

1. ___ No leaks: shaft, rudder, stuffing box, or shaft log.

2. ___ Propeller shaft coupling bolts lockwired and coupling is secured.

3. ___ With fuel tanks full, no leaks at fill pipes, overflow vent, or any fuel line connections.

4. ___ With coupling disconnected, engine and shaft alignment OK.-Recheck alignment after rigging tuned.

5. ___ Transmission oil level OK.

6. ___ Crank case oil level OK.

7. ___ Fuel valves open, bleed and prime lines for diesel engine.

8. ___ Check that shaft is coupled and aligned to .003 maxim tolerance.

9. ___ Engine wiring OK, connections tight.

10. ___ Throttle control cable travel and brackets OK.

11. ___ Clutch control cable travel and brackets OK.

12. ___ Start engine.

13. ___ Exhaust water flow OK.

14. ___ No leaks in fuel lines at fittings, fuel filter, fuel pump or injectors.

15. ___ No engine or oil leaks.

16. ___ Idling speed set R.P.M.'s.

17. ___ Shutoff cable for diesel engine OK.

18. ___ Check forward and reverse shifting lever friction OK.

19. ___ Check engine instruments for operation, tachometer for calibration.

20. ___ Run in gear for ten (10) minutes minimum.

21. ___ Recheck packing gland after engine stops for-proper lubrication.


Back to Page 1   Goto Page 3

Back to The Catalina 27/270 Main Page